Chevrolet Spark manuals

Mazda CX-5 Service & Repair Manual: Fuel System

Purpose, Outline

Structural View

Engine compartment side


Fuel tank side

U.S.A. and CANADA (2WD)


U.S.A. and CANADA (AWD)


Except U.S.A. and CANADA (2WD)


Except U.S.A. and CANADA (AWD)


System Diagram


Structure


Part/System name

Reference

Return-less fuel system

(See RETURNLESS FUEL SYSTEM [SKYACTIV-G 2.0].)

Fuel pump unit

(See FUEL PUMP UNIT [SKYACTIV-G 2.0].)

Direct fuel injection system

(See DIRECT FUEL INJECTION SYSTEM [SKYACTIV-G 2.0].)

High pressure fuel pump

(See HIGH PRESSURE FUEL PUMP [SKYACTIV-G 2.0].)

Fuel distributor

(See FUEL DISTRIBUTOR [SKYACTIV-G 2.0].)

Fuel injector

(See FUEL INJECTOR [SKYACTIV-G 2.0].)

Fuel tank

(See FUEL TANK [SKYACTIV-G 2.0].)

Non-return valve

(See NON-RETURN VALVE [SKYACTIV-G 2.0].)

Fuel pump relay

(See FUEL PUMP RELAY [SKYACTIV-G 2.0].)

Fuel injector relay

(See FUEL INJECTOR RELAY [SKYACTIV-G 2.0].)

Fuel pump control module

(See FUEL PUMP CONTROL MODULE [SKYACTIV-G 2.0].)

Quick connector (fuel system)

(See QUICK RELEASE (FUEL SYSTEM) CONNECTOR [SKYACTIV-G 2.0].)


Specification


Item

Specification

Fuel injector

Type

High resistance

Fuel supply method

Top-feed

Drive types

Electronic

Pressure regulator control pressure

(kPa {kgf/cm2, psi})

Approx. 430 {4.38, 62.4}

Fuel pump type

Electric

Fuel tank capacity

(L {US gal, Imp gal})

2WD

56.0 {14.8, 12.3}

AWD

58.0 {15.3, 12.8}


Fuel type


Fuel

Octane Rating* (Anti-knock index)

Regular unleaded fuel

87 [(R+M)/2 method] or above (91 RON or above)


* U.S. federal law requires that octane ratings be posted on gasoline station pumps.

Fuel Shut Off Valve
U.S.A. And CANADA Purpose, function Prevents fuel from flowing to the charcoal canister during tight turns or vehicle rollover. Releases evaporative gas to the charcoal canister. ...

Fuel Tank Inspection
WARNING: Fuel is very flammable liquid. If fuel spills or leaks from the pressurized fuel system, it will cause serious injury or death and facility breakage. Fuel can also irritate skin ...

Other materials:

D Pillar Trim Removal/Installation
1. Disconnect the negative battery cable.. 2. Remove the following parts: a. Trunk board. b. Trunk end trim. c. Rear scuff plate. d. Trunk side trim. 3. Take the shaded area shown in the figure, and remove the D-pillar trim in the direction of the arrow in the order of (1), (2), (3) wh ...

Refrigerant Pressure Sensor Inspection [Full Auto Air Conditioner]
1. Install the manifold gauge. 2. Verify the high-pressure side reading of the manifold gauge. 3. Measure the terminal voltage at PCM terminal 2BB, 2AX and 2AJ 4. Using the graph below, measure and verify the terminal voltages at 2AX. 5. Follow the PCM inspection when measuring the other te ...

Windshield Washer Nozzle Removal/Installation
1. Remove the following parts: a. Windshield wiper arm and blade. b. Cowl grille. 2. Disconnect the windshield washer hose from the windshield washer nozzle.. 3. While pressing windshield washer nozzle tabs in the direction of the arrow (1) shown in the figure, pull the windshield washer ...

© 2016-2019 Copyright www.mcx5.org