Chevrolet Spark manuals

Mazda CX-5 Service & Repair Manual: Rear Drive Shaft Removal/Installation

Mazda CX-5 Service & Repair Manual / Drivetrain / Driveline / Driveshafts / Rear Drive Shaft Removal/Installation

CAUTION:

1. Drain the rear differential oil into a container..

2. Remove in the order indicated in the table.

3. Install in the reverse order of removal.

4. After installation, add the specified rear differential oil..

5. Inspect the rear wheel alignment and adjust it if necessary..



1

Locknut

(See Locknut Installation Note.)

2

ABS wheel-speed sensor

.

3

Brake hose clip

4

Brake caliper component

5

Disc plate

6

Bolt (wheel hub)

(See WHEEL HUB COMPONENT REMOVAL/INSTALLATION [2WD].)

7

Wheel hub

(See Wheel Hub Removal Note.)

8

Dust cover

9

Rear drive shaft

(See Rear Drive Shaft Removal Note.)

10

Clip

(See Clip Installation Note.)


Wheel Hub Removal Note

1. Before removing the wheel hub, place alignment marks on the wheel hub and the hub support so that they can be installed to the same position before removal.

2. Remove the wheel hub.

CAUTION:

Rear Drive Shaft Removal Note

1. Pull the drive shaft toward the wheel side, then remove the drive shaft.

Clip Installation Note

1. Install a new clip onto the joint shaft with the opening facing upward. Ensure that the diameter of the clip does not exceed the specification on installation.

2. After installation, measure the outer diameter. If it exceeds the specification, repeat Steps 1—2 using a new clip.


Locknut Installation Note

1. After tightening the locknut once at a torque of 390 N·m {40 kgf·m, 288 ft·lbf}

, return it temporarily 180 degrees

, then retighten it to a torque of 236—274 N·m {25—27 kgf·m, 175—202 ft·lbf}

.

Rear Drive Shaft Inspection
1. Inspect each connecting part for looseness. Tighten or replace parts if necessary. 2. Inspect the dust boot on the drive shaft for cracks, damage, leaking grease, and looseness in t ...

Front Axle Assembly
...

Other materials:

Warranties for Your Mazda
• New Vehicle Limited Warranty • Powertrain Limited Warranty • Safety Restraint System Limited Warranty • Anti-perforation Limited Warranty • Federal Emission Control Warranty/California Emission Control Warranty • Emission Defect Warranty • Emission Performance Warranty • E ...

Liftgate Lower Trim Removal/Installation
1. Remove the following parts: a. Liftgate upper trim. b. Liftgate side trim. c. Liftgate recess. 2. Remove fasteners A. 3. Take the shaded area shown in the figure, and pull the liftgate lower trim in the direction of the arrow in the order of (1), (2), (3), (4) and remove it while ...

Rear Pillar (Outer) Installation [Panel Replacement]
Symbol Mark Installation Procedure 1. When installing new parts, measure and adjust the body as necessary to conform with standard dimensions. 2. Drill holes for the plug welding before installing the new parts. 3. After temporarily installing new parts, make sure the related parts fit p ...

© 2016-2022 Copyright www.mcx5.org