Chevrolet Spark manuals

Mazda CX-5 Service & Repair Manual: Rear Door Quarter Glass Removal/Installation

Mazda CX-5 Service & Repair Manual / Body / Glass & Windows / Rear Door Quarter Glass Removal/Installation

1. Fully lower the rear door glass.

2. Disconnect the negative battery cable..

3. Remove the rear door trim..

4. Remove the rear door weather strip arrow (1) shown in the figure.


5. Remove the service hole cover No.1 arrow (2) shown in the figure.

CAUTION:

6. Remove the service hole cover No.2 arrow in the order of (3), (4) shown in the figure.


7. Partially peel back rear door weather strip.


8. Remove screw B.

9. Remove bolts C.


10. Partially peel back the rear door glass run channel.


11. Pull the glass guide in the direction of the arrow (5) shown in the figure, then remove the glass guide direction of the arrow (6) shown in the figure..


12. Pull the rear door glass run channel in the direction of the arrow in the order of (7),(8),(9) then remove the rear door glass run channel.


13. Slide the rear door quarter glass and rear door quarter glass guide as a single unit in the direction of the arrow (10) shown in the figure.


14. Remove the rear door quarter glass and rear door quarter glass guide as a single unit in the direction of the arrow (11) shown in the figure.

15. Pull the rear door quarter glass guide in the direction of the arrow in the order of (12), (13), (14) and remove the rear door quarter glass.


16. Install in the reverse order of removal.

Rear Door Glass Run Channel Installation Note

Glass Guide Installation Note

1. Set the glass guide in the direction shown in the figure, and insert the bolt installation hole in the direction of arrow (1) until it reaches area A.


2. When the bolt installation hole of the glass guide reaches area A, rotate the glass guide in the direction of arrow (2) shown in the figure.

3. Move the glass guide in the direction of arrow (3) shown in the figure to adjust the position of the front door inner panel and the bolt installation holes of the glass guide.

4. Move the glass guide in the direction of arrow (4) shown in the figure and while aligning it to the screw installation hole in the rear door inner panel, set it to the rear door quarter glass and the rear door glass.


Rear Door Glass Removal/Installation
1. Fully lower the rear door glass. 2. Disconnect the negative battery cable.. 3. Remove the following parts: a. Rear door trim. b. Rear door quarter glass. c. Rear door speaker. d. Rear p ...

Rear Power Window Regulator Removal/Installation
1. Fully lower the rear door glass. 2. Disconnect the negative battery cable.. 3. Remove the following parts: a. Rear door trim. b. Rear door quarter glass. c. Rear door speaker. d. Rear p ...

Other materials:

Battery Recharging [Skyactiv G 2.0]
Using GR8-1291: (See GR8-1291 INSTANT TRAINING MODULE (VIDEO).) WARNING: Keep all flames away from the battery, otherwise evaporated gas from the battery fluid may catch fire and cause serious injury. 1. Remove the battery filler caps and check the water level. If necessary, add ...

Outer Mirror Glass Installation
1. Connect the mirror heater connectors. (with heated outer mirror) 2. Connect the blind spot monitoring (BSM) warning indicator light connector (with blind spot monitoring system). NOTE: Lightly pull the blind spot monitoring (BSM) warning indicator light connector and verify t ...

Cylinder Head Gasket Replacement
WARNING: A hot engine can cause severe burns. Turn off the engine and wait until it is cool before servicing. Fuel vapor is hazardous. It can very easily ignite, causing serious injury and damage. Always keep sparks and flames away from fuel. Fuel line spills and leakag ...

© 2016-2022 Copyright www.mcx5.org