Chevrolet Spark manuals

Mazda CX-5 Service & Repair Manual: Power Brake Unit Removal/Installation

Mazda CX-5 Service & Repair Manual / Brakes / General / Power Brake Unit Removal/Installation

CAUTION:

1. Remove the battery and battery tray..

2. Remove the windshield wiper arm and blade..

3. Remove the cowl grille..

4. Remove the windshield wiper motor and link..

5. Remove the cowl panel..

6. Remove the master cylinder..

7. Remove in the order indicated in the table.

8. Install in the reverse order of removal.

9. After installation, add brake fluid, bleed the air, and inspect for fluid leakage..

10. Remove the brake switch..

11. Inspect the brake pedal..

12. Install a new brake switch..



1

Vacuum hose

2

Snap pin

3

Clevis pin

4

Nut

5

Power brake unit

6

Gasket


Power Brake Unit Inspection
NOTE: The following inspection methods are simple inspection methods to judge the function of the power brake unit. If there is any malfunction in the power brake unit, replace the ...

R 3 5 Brake [Fw6 A EL, Fw6 Ax EL]
Purpose/Function The R-3-5 brake operates in 3GR, 5GR and in reverse to lock the reduction internal gear against rotation. Construction The R-3-5 brake consists of the following ...

Other materials:

Front Over Fender Removal/Installation
1. Remove fastener A. 2. Pull the front over fender lower in the direction of the arrow (1) while removing hook B and pin C. 3. Remove fasteners D. 4. Pull the front over fender upper in the direction of the arrow (2) while removing clips E. 5. Install in the reverse order of ...

Wiper Blades
CAUTION ●Hot waxes applied by automatic car washers have been known to affect the wiper's ability to clean windows. ● To prevent damage to the wiper blades, do not use gasoline, kerosene, paint thinner, or other solvents on or near them. ● When the wiper lever is in the ...

Map Light Bulb Removal/Installation
Front Map Light 1. Disconnect the negative battery cable.. 2. To prevent scratches or damage, affix protective tape to the position shown in the figure. CAUTION: If a flathead screwdriver is inserted into the gap between the front map light and lens, the front map light could inter ...

© 2016-2022 Copyright www.mcx5.org