Mazda CX-5 Service & Repair Manual: A/C Unit
Outline
-
The A/C unit which integrates the cooling and heater units has been adopted.
Construction
-
The A/C unit consists of the following parts.
Operation
Air Mix Door Operation
-
The air mix door, installed in the A/C unit, controls HOT or COLD position, depending on the position of the temperature control dial. As a result, airflow distribution changes, and the airflow temperature is controlled.
Airflow Mode Door Operation
-
The airflow mode doors move to VENT, BI-LEVEL, HEAT, DEF/HEAT, or DEFROSTER position, depending on the position of the airflow mode selector dial. As a result, airflow mode changes.
Fail-safe
-
Function not equipped.
A/C Cut Off Control [Skyactiv G 2.0]
Outline
Controls the A/C operation by switching the A/C relay ON/OFF at the optimal
timing according to engine operation conditions. Acceleration performance and
A/C compressor reliabilit ...
A/C Unit Disassembly/Assembly
1. Disassemble in the order indicated in the table.
CAUTION:
If a non-specified grease is used, it may result in abnormal noise or improper
operation of the links. Apply only the specifie ...
Other materials:
Customer Assistance (Canada)
Satisfaction Review Process
Your complete and permanent satisfaction is of primary concern to Mazda. All
Authorized Mazda Dealers have both the knowledge and tools to keep your Mazda in
top condition. In our experience, any questions, problems, or complaints regarding
the operation of your Ma ...
Lubrication System
Outline
Pressure loss is reduced by optimizing the oil passage.
With the adoption of the chain drive type oil pump, oil pump drive force
has been reduced.
With the adoption of the oil shower pipe, sliding resistance has been reduced.
With the adoption of the engine ...
Clock Removal/Installation
1. Disconnect the negative battery cable..
2. Remove the following parts:
a. Shift lever knob (MTX).
b. Front console box.
c. Shift panel.
d. Upper panel.
e. Rear console.
f. Side wall.
g. Decoration panel.
h. Front console.
i. Glove compartment.
j. Climate control unit.
3. P ...
